|
MSDS
Name
|
United
Duct Sealer Water Based
|
|
Revision
Date
|
February 1, 2010
|
Section
1: Chemical Product and Company Identification
|
Product Name
|
United
Duct Sealer Water Based
|
|
CAS Number
|
none
|
|
HMIS Hazard Rating
|
Health: 1, Fire: 1, Reactivity: 0
|
|
Company
Identification |
McGill AirSeal LLC
2400 Fairwood Avenue Columbus, Ohio 43207 |
|
Contact
|
McGill AirSeal LLC
|
|
Telephone
|
(800)624-5535,
(614)829-1200
|
|
Fax
|
(614)829-1488
|
|
Chemtrec
(24-hour) |
(800)424-9300
|
|
Chemtrec
International |
(703)527-3887
|
|
Product Class
|
polymer dispersed in water
|
|
Product Use
|
duct sealer
|
|
Product
Code
|
5871,
5872, 5876, 5877, 5878
|
Section 2: Composition and Information about Ingredients
|
Hazardous Ingredients
|
CAS Number
|
Percent
|
|
Product
contains no hazardous ingredients or they are below reportable levels.
|
||
|
OSHA
PELs and ACGIH TLVs are listed in Section 8 where applicable.
|
||
Section 3: Hazard Identification
|
Emergency
Overview |
Material
is a gray mastic that is slippery in the wet state.
|
|
Routes of Entry
|
Inhalation: Yes; Ingestion: Yes; Skin: Yes; Eye: Yes
|
|
Inhalation
|
May be irritating to
upper respiratory tract.
|
|
Ingestion
|
Ingestion is not a probable
route of exposure. Harmful if swallowed.
|
|
Skin
|
Prolonged or repeated skin
contact can cause irritation.
|
|
Eye
|
Mildly irritating to eyes.
|
|
Medical Conditions
Aggravated by Exposure |
Under conditions of normal use
chronic affects are not expected. Possible aggravation of pre-existing skin conditions.
|
|
Carcinogenicity
|
IARC: No; NTP: No;
OSHA: No
|
|
Reproductive Toxicity
|
This product has not been
evaluated for reproductive toxicity.
|
|
Target Organs
|
Eyes and skin
|
Section 4: First Aid Measures
|
Inhalation
|
Remove to fresh air. If
difficulty persists seek medical attention.
|
|
Ingestion
|
Call poison control
center immediately. Follow their specific instructions. Do not induce vomiting.
|
|
Skin
|
Wash with soap and water.
Contact a physician if irritation develops or persists.
|
|
Eye
|
Hold eyelids apart and flush
with plenty of water for at least 15 minutes. Seek medical attention.
|
Section 5: Fire-Fighting Measures
|
Flammability Class
(OSHA) |
IIIB
|
|
Flash Point
|
>200°F; Setaflash
|
|
Explosive Range
|
Not
applicable
|
|
Extinguishing Media
|
Use alcohol foam, carbon
dioxide, water spray, or ABC dry chemical when fighting fires involving this product.
|
|
Hazardous Combustion
Products |
Oxides of carbon
may be released during combustion.
|
|
Fire-Fighting Procedures
|
Wear a NIOSH approved
self-contained breathing apparatus.
|
Section 6: Accidental Release Measures
|
Containment
Techniques
|
Use inert absorbent to dike the spill. Keep away from drains. |
|
Clean-up
|
Spread absorbent over
material and scrape up material/absorbent and place in an approved container. If product has
dried, scrape up and place in an approved container.
|
|
Emergency Measures
|
Isolate hazard area. Keep
unnecessary and unprotected personnel from entering area. Wear all appropriate personal
protection equipment (PPE) (See Section 8).
|
Section 7: Handling and Storage
|
Handling
|
Wash thoroughly after handling.
Avoid prolonged or repeated contact with skin.
|
|
Storage
|
Keep from freezing.
|
|
Precautionary
Statement |
KEEP OUT OF THE REACH
OF CHILDREN.
|
Section 8: Exposure Controls and Personal Protection
|
Occupational
Exposure Limits
|
||
|
ACGIH
TLV
|
Not
Applicable
|
|
|
ACGIH
TLV-C
|
Not Applicable
|
|
|
ACGIH
STEL
|
Not Applicable
|
|
|
OSHA
STEL
|
Not Applicable
|
|
|
OSHA
PEL
|
Not Applicable
|
|
|
Engineering
Controls
|
Use local exhaust as needed to
maintain occupational exposure limits.
|
|
Other
|
Facilities storing or utilizing
any chemical should be equipped with an eyewash facility and a safety shower.
|
|
Respiratory
Protection |
Respiratory
protection is not expected to be necessary under normal use. Follow
requirements for respiratory protection in OSHA 1910.134.
|
|
Eye Protection
|
Chemical splash goggles (ANSI
Z87.1 or approved equivalent).
|
|
Skin Protection
|
Where skin contact can occur,
wear impervious gloves.
|
Section 9: Physical and Chemical Properties
|
Form
|
mastic
|
|
Appearance/Color
|
gray
|
|
Odor
|
mild
|
|
Solubility (in water)
|
miscible
|
|
pH Value
|
7.5 |
|
Boiling
Range/Point
|
212°F |
|
Evaporation Rate
|
slower than n-Butyl Acetate
|
|
% Volatile
|
34.0%
|
|
Specific Gravity
|
1.33
|
|
VOC
|
1.2 g/l
|
Section 10: Stability and Reactivity
|
Stability
|
This product is stable.
|
|
Hazardous
Polymerization |
Hazardous polymerization
will not occur.
|
|
Conditions
to Avoid |
Strong acids and strong bases
|
|
Incompatibility
|
Easily oxidizable materials
|
Section 11: Toxicological Information
|
This
formulation has a low odor of acute and chronic toxicity by all routes
of exposure. Prolonged or repeated exposure may cause skin irritation.
Direct contact may cause eye irritation. Exposure to any chemical
substance, including those with a low order of toxicity, should be
controlled and minimized to avoid harmful effects.
|
Section 12: Ecological Information
|
This formulation has not
been tested for environmental effects.
|
Section 13: Disposal Considerations
|
Waste Disposal
|
Disposal of this product must
comply with all applicable federal, state, and local regulations.
|
|
Container Disposal
|
Disposal of this container
should comply with all applicable federal, state, and local regulations.
|
Section 14: Transport Information
|
UN Number: None
UN Pack Group: Not Applicable UN Class: Nonhazardous ICAO/IATA Class: Nonhazardous IMDG Class: Nonhazardous Shipping Name: Nonhazardous |
|
|
Packaging
may not be approved for shipping by air. Contact McGill AirSeal for further information.
|
|
Section 15: Regulatory Information
|
TSCA (Toxic Substances Control Act Inventory)
|
|
|
All components of this
product are listed on the TSCA inventory except as exempted.
|
|
Pennsylvania
|
|
|
Hazardous components required to be listed at 1% or more
|
calcium carbonate; limestone; 1317-65-3
clay, kaolin; 1332-58-7 |
|
Non-hazardous components required
to be listed at 3% or more
|
dipropylene
glycol dibenzoate; 27138-31-4
water; 7732-18-5 polyvinyl acetate emulsion; 24980-61-8 polymerized rosin; 65997-05-9 |
|
New Jersey
|
dipropylene
glycol dibenzoate; 27138-31-4
calcium carbonate; 1317-65-3 polymerized rosin; 65997-05-9 water; 7732-18-5 polyvinyl acetate emulsion; 24980-61-8 |
Section 16: Other Information
|
Disclaimer
|
While the information and
recommendations set forth herein are believed to be accurate as of the data hereof,
McGill AirSeal LLC makes no warranty, express or implied, with respect thereto and disclaims all
liability from reliance thereon.
|
©
Copyright 2001-2011 McGill AirSeal LLC
e-mail us: sales@mcgillairseal.com
An
enterprise of United McGill Corporation—Family owned and operated since 1951
All the trademarks (™) and registered trademarks (®) in this
Web site are the property of United McGill Corporation.